If this is your first visit, be sure to check out the FAQ by clicking the link above. You may have to register before you can post: click the register link above to proceed. To start viewing messages, select the forum that you want to visit from the selection below. |
|
|
Thread Tools | Display Modes |
#1
|
|||
|
|||
'84 diesel rabbit still emitting white smoke after header gasketreplaced
we just finished replacing the header gasket on my '84 diesel rabbit.
it started right up and it seems to run OK. there's a little white smoke and it runs a little bit rough for the first few minutes after it starts up, but it's orders-of-magnitude better than it was before. periodically though, it hiccups, runs a little rough, and here comes the white smoke again. could this be a timing issue? |
Ads |
#2
|
|||
|
|||
'84 diesel rabbit still emitting white smoke after header gasketreplaced
On Apr 6, 10:47*am, Reid Fleming > wrote:
> we just finished replacing the header gasket on my '84 diesel rabbit. > it started right up and it seems to run OK. *there's a little white > smoke and it runs a little bit rough for the first few minutes after > it starts up, but it's orders-of-magnitude better than it was before. > periodically though, it hiccups, runs a little rough, and here comes > the white smoke again. *could this be a timing issue? Reid It sounds as if the injection pump is out of time. You need to get info on how to set the injection pump. It requires a special tools but if you are inventive you can improvise. Mike |
#3
|
|||
|
|||
'84 diesel rabbit still emitting white smoke after header gasket replaced
You could have a crack in the head or block that the head gasket would not
correct. You did torque the bolts in the correct order and torque steps, I'm sure. Also, did you check the head and block deck for flatness? Could be warped. Sounds like you are going to do it again. Sorry. ( "mdsimon" > wrote in message ... On Apr 6, 10:47 am, Reid Fleming > wrote: > we just finished replacing the header gasket on my '84 diesel rabbit. > it started right up and it seems to run OK. there's a little white > smoke and it runs a little bit rough for the first few minutes after > it starts up, but it's orders-of-magnitude better than it was before. > periodically though, it hiccups, runs a little rough, and here comes > the white smoke again. could this be a timing issue? Reid It sounds as if the injection pump is out of time. You need to get info on how to set the injection pump. It requires a special tools but if you are inventive you can improvise. Mike |
Thread Tools | |
Display Modes | |
|
|
Similar Threads | ||||
Thread | Thread Starter | Forum | Replies | Last Post |
81 Rabbit diesel A/C Issues | backwoods | VW water cooled | 6 | January 14th 07 08:52 PM |
1980 VW diesel Rabbit | sadle1dc | VW water cooled | 2 | August 1st 06 08:53 PM |
AWA [OFFER] Moly Shield Diesel Fuel Smoke Supressant & Flow Improver | [email protected] | General | 0 | January 12th 06 03:53 AM |
Power Steering in an '84 Diesel Rabbit? | Bryan K. Walton | VW water cooled | 8 | January 11th 06 02:31 AM |
black smoke from a diesel. | wenden1 | 4x4 | 11 | September 5th 05 07:41 PM |