If this is your first visit, be sure to check out the FAQ by clicking the link above. You may have to register before you can post: click the register link above to proceed. To start viewing messages, select the forum that you want to visit from the selection below. |
|
|
Thread Tools | Display Modes |
#11
|
|||
|
|||
Nedavno Steve Sears pise:
| The system in the 1987 Audi 5000 Turbo/200 used a deceleration valve, | the failure of which could result in the engine stalling (it cuts the | fuel delivery off to the engine when the car decelerates, thus | reducing fuel consumption) - but that is for the fuel system, which | your LPG system is not using. Yes, but from: http://www.sjmautotechnik.com/troubl...sys.html#decel "These valves have been known to stick open and then not shut when the RPM drops below 1200 which causes the big vacuum leak and the stalling" So if deceleration valve is not completely stick, but slow in response (close to sticking, but still works) I would have vacuum leak. I do not knew if this is possible. | There's a Russian web site that has all | the parts diagrams Yes, I knew, I found it some time ago, its: http://www.elcats.ru/audivw/nn/ I was searching there and on page: http://www.elcats.ru/audivw/nn/vag4....1988&cyl=&vol= when you click on nine-th item from the top, and then on the button below the picture on the left, (NF engine) there is no decel valve. But if you click on the eighth item from the top and then on the button below the picture on the left, (MC engine) there is one. So it seems that I do not have one. What about EGR valve? Where is it? I can not find it either on Russian site. Do I have it? Can that be the problem? | I think you should give all of the | intake hoses a real close check for cracks or leaks - also in the | connections between the LPG system and the car's original system hoses | - the underside of the intake hoses rots out first due to oil from the | crankcase recirculation (and turbo leaks). When the car is idling, | the intake is under a vacuum and may cause an intermittent leak in a | broken hose - changing the fuel/LPG mixture and thus the idle. I already checked intake hoses. Only breather hose was broken, and I replaced it. -- ___ ____ /__/ / \ ** Registrovani korisnik Linuksa #291606 ** / / \/ /\ \ ** http://counter.li.org/ ** /__/\____/--\__\ ** Reply at: iimperl - at - ml1 - dot - net ** |
Ads |
#12
|
|||
|
|||
Yvan,
I think that the oxygen sensor and the catalytic converter led to the demise of the EGR valve - my 1980 5k (WD-code engine) has one (and no OXS or cat. converter), but my 1987 5ktq (MC-code engine) does not. Cheers! Steve Sears 1987 Audi 5kTQ 1980 Audi 5k 1962 and '64 Auto Union DKW Junior deLuxes (SPAM Blocker NOTE: Remove SHOES to reply) |
#13
|
|||
|
|||
Nedavno Steve Sears piše:
| I think that the oxygen sensor and the catalytic converter led to the | demise of the EGR valve - my 1980 5k (WD-code engine) has one (and no | OXS or cat. converter), but my 1987 5ktq (MC-code engine) does not. Thanks for all your help. I will check once again all the vacuum hoses, maybe replace some of them will ones for fuel or radiator hoses be good? If nothing gets better I'll have admit defeat and go to mechanic :-( -- ___ ____ /__/ / \ ** Registrovani korisnik Linuksa #291606 ** / / \/ /\ \ ** http://counter.li.org/ ** /__/\____/--\__\ ** Reply at: iimperl - at - ml1 - dot - net ** |
#14
|
|||
|
|||
Yvan,
Someone on Audifans wrote that using an _UNLIT_ propane torch (with the car outside in a well ventilated area, etc. etc.), you could find intermittent vacuum leaks by flowing the stream of propane gas over the intake hoses with the engine running. If the engine rpm raised with the torch tip near a hose or connector, there would be a good chance there was a leak in that area. I've never done that test, and of course you know that propane can burn and blow stuff up, but it's a test others have used successfully. No probs on the help. Cheers! Steve Sears 1987 Audi 5kTQ 1980 Audi 5k 1962 and '64 Auto Union DKW Junior deLuxes (SPAM Blocker NOTE: Remove SHOES to reply) |
#15
|
|||
|
|||
Nedavno Steve Sears pise:
| Someone on Audifans wrote that using an _UNLIT_ propane torch (with | the car outside in a well ventilated area, etc. etc.), you could find | intermittent vacuum leaks by flowing the stream of propane gas over | the intake hoses with the engine running. If the engine rpm raised | with the torch tip near a hose or connector, there would be a good | chance there was a leak in that area. I've never done that test, and | of course you know that propane can burn and blow stuff up, but it's a | test others have used successfully. No probs on the help. Thanks again for all your help. -- ___ ____ /__/ / \ ** Registrovani korisnik Linuksa #291606 ** / / \/ /\ \ ** http://counter.li.org/ ** /__/\____/--\__\ ** Reply at: iimperl - at - ml1 - dot - net ** |
#16
|
|||
|
|||
Steve Sears wrote:
>I've never done that test, and of course you know that propane can burn and >blow stuff up, but it's a test others have used successfully. Can't one just use startpilot? Startpilot is a spray which is useful for carburator engines if they don't want to start. Spray it into the air intake during turning of the engine. I suppose it's alcohol or ethane. Should provide the same result as it's made for that purpose, but it could possibly be a bit safer than propane. Don't know, however, what the english brandname is. Regards Wolfgang -- 1999 Audi A6 Avant TDI |
#17
|
|||
|
|||
Wolfgang,
That sounds like the "Quickstart" that my dad used to use to get the old '68 Dodge Monaco going on cold mornings - it's ether. I've also heard of using WD40. The propane method sounds good because you're not waiting for the last spot you sprayed to dry up before you move on to check a different hose. Cheers! Steve Sears 1987 Audi 5kTQ 1980 Audi 5k 1962 and '64 Auto Union DKW Junior deLuxes (SPAM Blocker NOTE: Remove SHOES to reply) "Wolfgang Pawlinetz" > wrote in message ... > Steve Sears wrote: > > >I've never done that test, and of course you know that propane can burn and > >blow stuff up, but it's a test others have used successfully. > > Can't one just use startpilot? Startpilot is a spray which is useful > for carburator engines if they don't want to start. Spray it into the > air intake during turning of the engine. I suppose it's alcohol or > ethane. > > Should provide the same result as it's made for that purpose, but it > could possibly be a bit safer than propane. > > Don't know, however, what the english brandname is. > > Regards > > Wolfgang > > -- > 1999 Audi A6 Avant TDI |
#18
|
|||
|
|||
Nedavno Steve Sears pise:
| Wolfgang, | That sounds like the "Quickstart" that my dad used to use to get the | old '68 Dodge Monaco going on cold mornings - it's ether. I've also | heard of using WD40. The propane method sounds good because you're | not waiting for the last spot you sprayed to dry up before you move on | to check a different hose. It sounds dangerous to me. If I have bad spark plug wire, or exhaust is leaking, I cold burn car or myself :-) -- ___ ____ /__/ / \ ** Registrovani korisnik Linuksa #291606 ** / / \/ /\ \ ** http://counter.li.org/ ** /__/\____/--\__\ ** Reply at: iimperl - at - ml1 - dot - net ** |
#19
|
|||
|
|||
Nedavno Steve Sears pise:
| The propane method sounds good because you're | not waiting for the last spot you sprayed to dry up before you move on | to check a different hose. Does my (5 cyl, 2.3 NF normally aspirated) engine have PCV (positive crankshaft ventilation) valve? If it does, where is it? I'd like to check it. -- ___ ____ /__/ / \ ** Registrovani korisnik Linuksa #291606 ** / / \/ /\ \ ** http://counter.li.org/ ** /__/\____/--\__\ ** Reply at: iimperl - at - ml1 - dot - net ** |
#20
|
|||
|
|||
Yvan,
No, I don't believe that it has a valve, but it should have a vent hose that collapses over time. Cheers! Steve Sears 1987 Audi 5kTQ 1980 Audi 5k 1962 and '64 Auto Union DKW Junior deLuxes (SPAM Blocker NOTE: Remove SHOES to reply) "Yvan" > wrote in message ... > Nedavno Steve Sears pise: > > | The propane method sounds good because you're > | not waiting for the last spot you sprayed to dry up before you move on > | to check a different hose. > > Does my (5 cyl, 2.3 NF normally aspirated) engine have PCV (positive > crankshaft ventilation) valve? If it does, where is it? I'd like to > check it. > > > > -- > ___ ____ > /__/ / \ ** Registrovani korisnik Linuksa #291606 ** > / / \/ /\ \ ** http://counter.li.org/ ** > /__/\____/--\__\ ** Reply at: iimperl - at - ml1 - dot - net ** |
Thread Tools | |
Display Modes | |
|
|
Similar Threads | ||||
Thread | Thread Starter | Forum | Replies | Last Post |
driving on flat tyre ? | NC | Alfa Romeo | 4 | January 7th 05 11:23 AM |
Driving the Spider | Dr Entropy | Alfa Romeo | 0 | July 19th 04 07:26 AM |
Headlight mods for driving abroad | Toby Groves | Audi | 0 | June 10th 04 11:01 PM |
Cost of repair Audi BMW Saab...(crossposting) | dizzy | Audi | 44 | May 23rd 04 09:58 PM |
Audi A4 TV module - view whilst driving? | Russell Fray | Audi | 7 | May 14th 04 08:32 PM |